Boiler Equipment And Steam System
We offer Boiler Equipment And Steam System and Condensate Recycle System as below:
Boiler Equipments (Steam Generator)
Clean energy, good efficiency and zero emissions
The steam generator is a new product with clean energy, good efficiency and zero emissions. It has changed the situation of high pollution and low steam quality of traditional electric wire heating boiler and coal-fired boiler in the past. The product can be used in the paper products industry of multilayer cardboard, drying, drying.
90 seconds steam
1, 90 seconds steam compared with resistance wire heating, heating power density is greater, 90 seconds can be steam, save time and save money! It takes 30 minutes to 60 minutes for coal-fired boiler to steam.
zero emission
2, Zero emission, green environmental protection, inspection-free products, supported by the Ministry of Environmental Protection. Coal boiler has serious pollution and high energy consumption, which is the focus of national governance.
greatly save the cost
AUTOMATIC INTELLIGENCE CONTROL OF STEAM SYSTEM AND CONDENSATE RECYCLE SYSTEM OF WHOLE PRODUCTION LINE
Benefits of steam condensate recovery:
1. After steam condensate recovered, then pump return to boiler for using, can greatly save the boiler fuel cost, reduce the production cost.
2. The condensed water is distilled water, solid component not containing scale, if be recycling can save a lot of boiler cleaning cost, water and electricity.
3. To improve the quality of the boiler water, also the steam quality will be improved and the boiler’s exhaust will be reduces, in order to save energy.
4 condensation water’s recycling can reduce the supply water, no matter inside nor outside of the boiler water will reduce the and the treatment costs.
5. Water temperature increased, the oxygen content in the water is reduced, which can avoid the boiler, engine, corrosion and steam pipe rust, in the mean time, the air is reduced, it will increase the heat transfer rate, improve the efficiency of the machine.
6. Water temperature increased, that will avoid the steel plate thermal and stress is not balanced, prolong the service life of the boiler.
7. Feed water and boiler water temperature difference is small, the pressure of the steam boiler will be stability.
8. Water temperature increase will increase the boiler evaporation, it will better able to cope with and boiler load change, and reduce the spare pot using opportunity.
9. After using condensate, it will without the steam and noise pollution, improve the working environment.
10. Increase water temperature, reducing the need for per unit production of steam heat to save fuel consumption, improves the pot efficiency of furnace.
Main features of our Steam System And Condensate Recycle System:
The production is sophisticated, integrated combination machine, simple installation, suitable for every kind of boiler use.
1. The machine is module design, comprehensive, does not need to add any auxiliary equipment.
2. Impeller already pass the balance experiment of dynamic (Dynamic Balance Test), smoothing use, no shaking phenomenon.
3 With saturated pressure device, stable and quiet using, without Cavitations.
4 Use high sensitive instrument control system, precise induction, safety is especially good.
5 The unit has water safety control system, in order to avoid machine condensed water recovery of a large volume into boiler then caused accident.
6. Our device suitable for a large range of boiler sizes, the important part all adopts the advanced components, after installation can be long-term stable use.
7 Forced the condensed water is sucked back into the recovery tank, safety and no condensate accumulation, so the efficiency increases.
8 The condensed water can not be accumulated equipment, no water hammer phenomenon; can prolong the service life of equipment.
The economic benefit of STEAM AND CONDENSATE RECYCLE SYSTEM :
1 Can save more than 20% fuel
2 Save a lot of boiler fee, water and electricity
3 Save a lot of water treatment costs
4 Increase heat transfer rate, improve the efficiency of the machine
5 Boiler water temperature difference is small, stable steam pressure
6 To improve the boiler efficiency, prolong the service life of the boiler
